1. Oil leakage at the compressor end of the supercharger caused by oil and gas accumulation at the pressure housing outlet: Check the supercharger and confirm that the supercharger is a qualified product. Generally, it can be analyzed from the use of the supercharger. If the dust in the operating environment is large, causing the air filter to block and causing a negative pressure of over 5.5kPa, it will cause oil leakage at the compressor end of the supercharger; When a car is driving down a steep slope in a mountainous area, the biogas generator unit will drive at a low speed for more than 15 minutes without the fuel filler door. Failure to establish a gas seal on the back of the medium pressure impeller of the supercharger to form a vacuum can also cause oil leakage at the compressor end of the supercharger. As long as the air filter is regularly maintained, the idling time of the biogas generator set should not be too long, and this false oil leakage phenomenon can be eliminated.

2、機油壓力過高會引起增壓器漏油：沼氣發電機組增壓器的進油壓力過高也是引起增壓器漏油的原因之一。當我們經檢查確認增壓器是合格品，而又發現沼氣發電機組的機油壓遠高于說明書的規定，則要檢查沼氣發電機組的潤滑系統，調壓閥是否卡死或失靈，沼氣發電機組的機油壓力正常了，增壓器的漏油即可排除。

2. High oil pressure can cause oil leakage in the supercharger: High oil inlet pressure in the supercharger of biogas generator sets is also one of the reasons for oil leakage in the supercharger. When we confirm that the supercharger is a qualified product through inspection and find that the oil pressure of the biogas generator unit is much higher than the specification, we should check whether the lubrication system of the biogas generator unit and the pressure regulating valve are stuck or malfunctioning. If the oil pressure of the biogas generator unit is normal, the oil leakage from the supercharger can be eliminated.

3、回油不暢會造成增壓器漏油：沼氣發電機組增壓器的回油是靠油的自重從增壓器回油管回入沼氣發電機組中，如果回油管出現縮節和阻塞，增壓器的回油不暢，增壓器會出現兩端滲漏機油。應排除回油不暢，在增壓器完好的情況下，故障也即排除。

3. Poor oil return can cause oil leakage from the supercharger: The oil return from the supercharger of a biogas generator unit is returned from the supercharger oil return pipe to the biogas generator unit by the weight of the oil. If the oil return pipe is shrunk or blocked, the oil return from the supercharger is not smooth, and oil leakage occurs at both ends of the supercharger. It should be ruled out that the oil return is not smooth, and if the supercharger is intact, the fault should be eliminated.

4、沼氣發電機組在施工中頻繁停車起動：沼氣發電機組在施工中頻繁停車起動，會引起增壓器中間殼渦輪端結焦；同時引起中間殼回油腔結焦，使增壓器回油腔縮小回油不暢產生漏油，應檢查各易損件是否完好，并清除結焦。

4. Frequent shutdown and startup of biogas generator units during construction: Frequent shutdown and startup of biogas generator units during construction can cause coking at the turbine end of the turbocharger intermediate casing; At the same time, it causes coking in the oil return cavity of the intermediate housing, which causes the oil return cavity of the supercharger to shrink and the oil return is not smooth, resulting in oil leakage. It is necessary to check whether all vulnerable parts are in good condition and remove coking.

5、沼氣發電機組竄氣嚴重會造成增壓器的回油不暢、增壓器漏油：有些增壓器發現漏油甚至兩端漏油，經檢查增壓器是合格品，進油回油也正常，再進行拆檢發現增壓器主軸中段有很厚的油垢還有些發硬，鏟除清洗后發現主軸中段變淡黃色且增壓器回油管中亦有油垢，從以上現象可以判斷為沼氣發電機組竄氣引起增壓器的回油不暢。更換沼氣發電機組四配套排除沼氣發電機組下竄氣，對增壓器、回油管進行清洗，故障即可排除。

5. Serious gas channeling in biogas generator units can cause poor oil return from the supercharger and oil leakage from the supercharger: Some superchargers have found oil leakage, even at both ends. Upon inspection, the supercharger is qualified, and the oil inlet and return are also normal. After disassembly and inspection, it is found that there are thick oil stains and some hardening in the middle section of the supercharger's main shaft. After cleaning, it is found that the middle section of the main shaft turns pale yellow and there are also oil stains in the supercharger's oil return pipe, From the above phenomenon, it can be judged that the blowby of the biogas generator unit causes the oil return of the supercharger to be blocked. Replace the four matching biogas generator sets to eliminate the downward blowby of the biogas generator set, and clean the supercharger and oil return pipe. The fault can be eliminated.